航天推进技术研究院主办
[1]王浩明,陈金利,王园丁,等.基于运行状态的氦氙布雷顿循环气体组分分析[J].火箭推进,2023,49(03):76-82.
WANG Haoming,CHEN Jinli,WANG Yuanding,et al.Gas composition analysis of helium-xenon Brayton cycle based on operating status[J].Journal of Rocket Propulsion,2023,49(03):76-82.
点击复制
WANG Haoming,CHEN Jinli,WANG Yuanding,et al.Gas composition analysis of helium-xenon Brayton cycle based on operating status[J].Journal of Rocket Propulsion,2023,49(03):76-82.
基于运行状态的氦氙布雷顿循环气体组分分析
《火箭推进》[ISSN:1672-9374/CN:CN 61-1436/V]
卷:
49
期数:
2023年03期
页码:
76-82
栏目:
目次
出版日期:
2023-06-25
- Title:
- Gas composition analysis of helium-xenon Brayton cycle based on operating status
- 文章编号:
- 1672-9374(2023)03-0076-07
- Keywords:
- Brayton cycle; helium-xenon mixture; operating status; dynamic simulation; gas composition
- 分类号:
- V476.2
- 文献标志码:
- A
- 摘要:
- 氦氙气体的组分保持是氦氙布雷顿能量转换系统长期稳定运行的基础,而无论是工质气体的泄漏还是充填量的调节都有可能导致系统中的氦氙气体组分发生变化,进而影响系统运行状态。通过对氦氙布雷顿系统的动态仿真计算,得到了气体组分发生变化时系统运行的差异。当气体组分发生变化时,系统共同工作线将发生偏移,尤其是气体摩尔质量变小时,共同工作线向喘振线偏移; 并且在到达满功率输出时,压气机喘振裕度变小,且需要更高的涡轮入口温度; 同时会导致回热器热侧温度入口提高,不利于系统的稳定运行。基于系统仿真结果提出了在额定转速下以负荷率、流量为变量的氦氙气体组分计算方法,为实现氦氙布雷顿循环工质组分变化的监控和调节提出了新思路。该方法中,流量的精确测量是提高组分分析精度的重要保障。
- Abstract:
- Gas composition maintenance of helium-xenon mixture is the basis for the long-term stable operation of the helium-xenon brayton energy conversion system. However, composition of the helium-xenon gas in the system may change because of working gas leakage or adjustment of filling amount, and then system operation status is affected. Through the dynamic simulation of the helium-xenon brayton system, the difference of the system operation status was obtained with the condition of the gas composition changing. When the gas composition changes, the common working line of the system will shift, especially when the gas molar mass becomes smaller, the common working line will shift to compressor surge line; and when the full power output is reached, the surge margin of the compressor will be smaller and higher inlet temperature of turbine and recuperator is required, which is not conducive to the stable operation of the system. Based on the system simulation results, this paper proposed a calculation method of helium-xenon gas composition with load rate and flow rate as variables at rated speed and put forward a new idea for monitoring and adjusting the change of working fluid composition in helium-xenon Brayton cycle. In this method, accurate measurement of flow rate is an important guarantee to improve the precision of component analysis.
参考文献/References:
[1] 胡古,赵守智.空间核反应堆电源技术概览[J].深空探测学报,2017,4(5):430-443.
[2] RITZ F,PETERSON C E.Multi-mission radioisotope thermoelectric generator(MMRTG)program overview[C]//2004 IEEE Aerospace Conference Proceedings.New York:IEEE,2004.
[3] WERNER J,LIVELY K,KIRKHAM D.A multi-mission radioisotope thermoelectric generator(MMRTG)for Mars 2020[C]//2017 IEEE Aerospace Conference.New York:IEEE,2017.
[4] VOSS S S,RODRIGUEZ E A,EL-GENK M S,et al.Russian TOPAZ II system test program(1970—1989)[C]//AIP Conference Proceedings.Albuquerque,New Mexico:AIP,1994.
[5] PONOMAREV-STEPNOI N N,KUKHARKIN N E,USOV V A.“Romashka” reactor-converter[J].Atomic Energy,2000,88(3):178-183.
[6] ROSEN R,SCHNYER A D.Civilian uses of nuclear reactors in space[J].Science & Global Security,1989,1(1/2):147-164.
[7] STANCULESCU A.The role of nuclear power and nuclear propulsion in the peaceful exploration of space[M].Vienna:International Atomic Energy Agency,2005.
[8] KOROTEEV A S,ANDIANOV D I,KAREVSKIY V,et al.Test bench for key components of megawatt class international power and propulsion system ground demonstration[C]//7th European Conference for Aeronautics and Space Sciences.Milan,Italy:[s.n.],2017.
[9] BARNETT J W.Nuclear electric propulsion technologies:Overview of the NASA/DOE/DOD nuclear electric propulsion workshop[C]//AIP Conference Proceedings.Albuquerque,New Mexico:AIP,1991.
[10] OLSON S.Mars opposition piloted nuclear electric propulsion(NEP)-chem vehicle[Z].2020.
[11] DATAS A,MART? A.Thermophotovoltaic energy in space applications:Review and future potential[J].Solar Energy Materials and Solar Cells,2017,161:285-296.
[12] MASON L S.A comparison of Brayton and Stirling space nuclear power systems for power levels from 1 kilowatt to 10 megawatts[C]//AIP Conference Proceedings.Albuquerque,New Mexico:AIP,2001.
[13] TORO C,LIOR N.Analysis and comparison of solar-heat driven Stirling,Brayton and Rankine cycles for space power generation[J].Energy,2017,120:549-564.
[14] OLUMAYEGUN O,WANG M H,KELSALL G.Closed-cycle gas turbine for power generation:A state-of-the-art review[J].Fuel,2016,180:694-717.
[15] 郭凯伦,王成龙,秋穗正,等.兆瓦级核电推进系统布雷顿循环热电转换特性分析[J].原子能科学技术,2019,53(1):16-23.
[16] TOURNIER J M,EL-GENK M,GALLO B.Best estimates of binary gas mixtures properties for closed brayton cycle space applications[C]//4th International Energy Conversion Engineering Conference and Exhibit(IECEC).Reston,Virginia:AIAA,2006.
[17] MASON L,SCHREIBER J.A historical review of brayton and stirling power conversion technologies for space applications[EB/OL].https://www.semanticscholar.org/paper/A-Historical-Review-of-Brayton-and-Stirling-Power-Mason-Schreiber/2fbcbd6db6c38452944eacda9b22cf4f240b7
a22,2007.
[18] MASON L S.A power conversion concept for the Jupiter icy moons orbiter[J].Journal of Propulsion and Power,2004,20(5):902-910.
[19] MASON L S.Power conversion concept designed for the Jupiter icy moons orbiter[R].NASA 20050192432.
[20] 王浩明,薛翔,张银勇,等.空间闭式布雷顿循环旁路调节特性分析[J].火箭推进,2021,47(2):61-67.
WANG H M,XUE X,ZHANG Y Y,et al.Analysis of bypass regulation characteristics for space closed Brayton cycle system[J].Journal of Rocket Propulsion,2021,47(2):61-67.
[21] 薛翔,杜磊,王浩明,等.闭式布雷顿循环核心机调控过程仿真分析[J].火箭推进,2021,47(5):49-55.
XUE X,DU L,WANG H M,et al.Simulation analysis of adjustment and control process for core machine in closed Brayton cycle[J].Journal of Rocket Propulsion,2021,47(5):49-55.
备注/Memo
收稿日期:2022-07-03; 修回日期:2022-07-23
基金项目:上海市科学技术委员会科研计划项目(19DZ1206502); 国家自然科学基金项目(u1967203)
作者简介:王浩明(1985—),男,博士,研究领域为空间推进系统及大功率热电转换技术。
更新日期/Last Update:
1900-01-01