航天推进技术研究院主办
[1]杨晨声,方 杰,蔡国飙,等.压力波对垂直管低温气液掺混冷凝的影响[J].火箭推进,2020,46(02):9-14.
YANG Chensheng,FANG Jie,CAI Guobiao,et al.Research on influence of pressure wave on mixing and condensation of cryogenic gas-liquid two-phase flow in vertical pipe[J].Journal of Rocket Propulsion,2020,46(02):9-14.
点击复制
YANG Chensheng,FANG Jie,CAI Guobiao,et al.Research on influence of pressure wave on mixing and condensation of cryogenic gas-liquid two-phase flow in vertical pipe[J].Journal of Rocket Propulsion,2020,46(02):9-14.
压力波对垂直管低温气液掺混冷凝的影响
《火箭推进》[ISSN:1672-9374/CN:CN 61-1436/V]
卷:
46
期数:
2020年02期
页码:
9-14
栏目:
研究与设计
出版日期:
2020-04-28
- Title:
- Research on influence of pressure wave on mixing and condensation of cryogenic gas-liquid two-phase flow in vertical pipe
- 文章编号:
- 1672-9374(2020)02-0009-06
- Keywords:
- vertical pipe; cryogenic gas-liquid two-phase flow; pressure wave; mixing and condensation; flow pattern; maximum axial condensation length; plume swing frequency
- 分类号:
- V434.3
- 文献标志码:
- A
- 摘要:
- 为了分析高压补燃液氧煤油发动机氧泵间管内气液两相掺混冷凝及其压力波传播过程,建立了可产生压力扰动的垂直管低温气液两相掺混实验系统,以氧气/液氧为实验工质,开展压力波对垂直管内低温气液两相掺混冷凝的影响研究,获得了不同压力波频率和氧气流量工况下的掺混图像,分析结果表明:压力波会使发散流型由微弱振荡冷凝向间歇振荡冷凝转变,使椭圆流型由稳定冷凝向振荡冷凝转变; 在0～52 Hz不同频率压力波作用下,发散流型最大轴向冷凝长度与掺混孔径之比在10～30之间,椭圆流型的比值在8～15之间变化; 压力波对气相摆动频率起主导性和正相关性的影响。
- Abstract:
- In order to study the gas-liquid mixing and condensation as well as the pressure wave propagation in the oxygen pump pipe of the high pressure staged combustion LOX/kerosene rocket engine, a cryogenic gas-liquid mixing in vertical pipe with pressure wave experiment system was constructed.The research on influence of pressure wave on mixing and condensation of cryogenic gas-liquid two-phase in vertical pipe was carried out with oxygen/LOX as working fluid.Interphase mixing images of different pressure wave frequencies and oxygen flow conditions were obtained.The results show that the pressure wave makes the divergent flow pattern change from weak oscillation condensation to intermittent oscillation condensation, and makes the elliptical flow pattern change from stable condensation to oscillation condensation.Under the influence of pressure waves with different frequencies from 0 to 52 Hz, the ratio of the maximum axial condensation length to the orifice diameter of the divergent flow pattern varies between 10 and 30, and the ratio of the elliptical flow pattern varies between 8 and 15.The pressure wave plays a leading and positive correlation to the plume swing frequency.
参考文献/References:
[1] 张贵田.高压补燃液氧煤油发动机[M].北京:国防工业出版社, 2005.
[2] 李向阳, 王晓锋, 宣统, 等.液氧/煤油发动机煤油预压涡轮泵技术[J].火箭推进, 2009, 35(1):16-20.LI X Y, WANG X F, XUAN T, et al.Techniques of kerosene booster turbopump for LOX/kerosene staged combustion cycle engine[J].Journal of Rocket Propulsion, 2009, 35(1):16-20.
[3] 张育林, 刘昆, 程谋森.液体火箭发动机动力学理论与应用[M].北京:科学出版社, 2005.
[4] 唐飞, 李家文, 李永, 等.热力学效应对低温诱导轮旋转汽蚀影响的数值研究[J].火箭推进, 2013, 39(2):29-34.TANG F, LI J W, LI Y, et al.Influence of thermodynamics effect on inducer rotating cavitation under low temperature condition[J].Journal of Rocket Propulsion, 2013, 39(2):29-34.
[5] CHUN M H, KIM Y S, PARK J W.An investigation of direct condensation of steam jet in subcooled water[J].International Communications in Heat and Mass Transfer, 1996, 23(7):947-958.
[6] PETROVIC D E WITH A, CALAY R K, DE WITH G.Three-dimensional condensation regime diagram for direct contact condensation of steam injected into water[J].International Journal of Heat and Mass Transfer, 2007, 50(9/10):1762-1770.
[7] XU Q, GUO L J, ZOU S F, et al.Experimental study on direct contact condensation of stable steam jet in water flow in a vertical pipe[J].International Journal of Heat and Mass Transfer, 2013, 66:808-817.
[8] KERNEY P J, FAETH G M, OLSON D R.Penetration characteristics of a submerged steam jet[J].AICHE Journal, 1972, 18(3):548-553.
[9] KIM Y S, YOUN Y J.Experimental study of turbulent jet induced by steam jet condensation through a hole in a water tank[J].International Communications in Heat and Mass Transfer, 2008, 35(1):21-29.
[10] LI Y Z, LI C, CHEN E F, et al.Pressure wave propagation characteristics in a two-phase flow pipeline for liquid-propellant rocket[J].Aerospace Science and Technology, 2011, 15(6):453-464.
[11] 李翠, 庄钰涵, 程亦薇, 等.低温气液两相流中压力波传播特性研究[J].低温工程, 2019(1):1-6.
[12] LI X D, ZHANG H, WANG R S, et al.MUSIG modeling and evaluation of nitrogen bubble coalescence in a bottom-closed vertical tube[J].Aerospace Science and Technology, 2010, 14(3):203-212.
[13] 薛传发,方杰,方雪健,等.垂直管内气液两相掺混冷凝可视化研究[C]//中国航天第三专业信息网第三十五届技术交流会.北京:中国航天第三专业信息网,2014.
[14] 薛传发.垂直管道低温气液两相掺混的流型辨识[D].北京:北京航空航天大学,2015.
[15] 方雪健,方杰,刘雪峰,等.垂直管道氧气-液氧两相掺混轴向冷凝长度研究[C]//中国航天第三专业信息网第三十六届技术交流会.北京:中国航天第三专业信息网,2015.
[16] 方雪健.垂直管道气液两相掺混及其压力波研究[D].北京:北京航空航天大学,2016.
[17] 杨晨声.垂直管道气液两相掺混流压力波研究[D].北京:北京航空航天大学,2018.
[18] KUCZY SKI W, BOHDAL T, CHARUN H.Impact of periodically generated hydrodynamic disturbances on the condensation efficiency of R134a refrigerant in pipe mini-channels[J].Experimental Heat Transfer, 2013, 26(1):64-84.
[19] 方杰,薛传发,方雪健,等.一种适用于低温气液两相掺混的可视化试验装置:ZL201510012811.8[P].2017-07-11.
[20] 方杰,方雪健,杨晨声,等.一种适用于低温介质的压力扰动装置:ZL201610177596.1[P].2018-04-17.
备注/Memo
收稿日期:2018-08-13; 修回日期:2018-12-01基金项目:国家自然科学基金(51306007)作者简介:杨晨声(1993—),男,硕士,研究领域为液体火箭发动机低温两相流压力波
更新日期/Last Update:
2020-04-25