PDF下载 分享
[1]雪佳强,郭宁,孟伟,等.离子电喷雾推力器束电流数学模型与敏感性分析[J].火箭推进,2024,50(02):77-87.[doi:10.3969/j.issn.1672-9374.2024.02.008]
　XUE Jiaqiang,GUO Ning,MENG Wei,et al.Mathematical model and sensitivity analysis of beam current for ion electrospray thruster[J].Journal of Rocket Propulsion,2024,50(02):77-87.[doi:10.3969/j.issn.1672-9374.2024.02.008]
点击复制

离子电喷雾推力器束电流数学模型与敏感性分析

《火箭推进》[ISSN:1672-9374/CN:CN 61-1436/V] 卷: 50 期数: 2024年02期 页码: 77-87 栏目: 目次 出版日期: 2024-05-30
Title:
Mathematical model and sensitivity analysis of beam current for ion electrospray thruster
文章编号:
1672-9374202402-0077-11
作者:
雪佳强1; 郭宁1; 孟伟1; 杨三祥1; 李春波1; 王墨戈2
1.兰州空间技术物理研究所 真空技术与物理重点实验室,甘肃 兰州 730000; 2.国防科技大学 空天科学学院,湖南 长沙 410073
Author(s):
XUE Jiaqiang1;  GUO Ning1;  MENG Wei1;  YANG Sanxiang1;  LI Chunbo1; WANG Moge2
1.Science and Technology on Vacuum Technology and Physics Laboratory,Lanzhou Institute of Physics, Lanzhou 730000, China; 2.College of Aerospace Science and Engineering, National University of Defense Technology, Changsha 410073, China
关键词:
纯离子状态;  多点发射;  束电流预测;  数学模型;  Sobol敏感性分析
Keywords:
pure ionic regime;  multi-site emission;  beam current prediction;  mathematical model;  Sobol sensitivity analysis
分类号:
V439
DOI:
10.3969/j.issn.1672-9374.2024.02.008
文献标志码:
A
摘要:
虽然阵列式结构的离子电喷雾推力器具有小体积、高比冲、高推力分辨率等优点,但是其发展受到了缺乏理论研究的限制。针对该问题,基于多点发射现象发展了描述推力器束电流的数学模型,并通过智能优化算法对模型中的经验系数进行了辨识,研究了高、低电压下束电流及发射行为存在的不同特征。基于Sobol方法进行了全局敏感性分析,研究了发射体结构的几何参数对束电流的影响程度。模型计算结果与试验结果基本一致,当电压大于1.5 kV时,发射点基底半径与多孔储层孔隙半径相当,外加电场主要影响束电流的非线性增加; 电压小于1.5 kV时,发射点数量较少,基底半径是多孔储层孔隙半径的1.5倍,发射点数量是影响束电流大小的关键因素。敏感性分析结果表明,发射体尖端与提取极之间的距离对束电流的影响程度最大,其1阶敏感性指数为0.841,在加工制造中须严格控制其公差大小。
Abstract:
Although the ion electrospray thruster with an array emitter has advantages such as small volume, high specific impulse, and high thrust resolution, its development has been limited by the lack of theoretical researches. To address this issue, a mathematical model describing the beam current of the thruster based on the multi-site emission phenomenon was developed, and the empirical coefficients in the model were identified using intelligent optimization algorithms. The different characteristics of the beam current and emission behavior under high and low voltages were studied. Global sensitivity analysis based on the Sobol method was conducted to investigate the impact of geometric parameters of the emitter structure on the beam current. The model calculation results are basically consistent with the experimental data. When the voltage is greater than 1.5 kV, the base radius of the emission site is equivalent to the pore radius of the porous reservoir, and the external electric field mainly affects the nonlinear increase of the beam current. When the voltage is less than 1.5 kV, the number of emission sites is small, the base radius is 1.5 times the pore radius of the porous reservoir, and the number of emission sites is a key factor affecting the size of the beam current. The sensitivity analysis results show that the distance between the tip of the emitter and the extractor has the greatest impact on the beam current, with a first order sensitivity index of 0.841, and its tolerance must be strictly controlled in manufacturing processes.

参考文献/References:

[1] 郭登帅, 康小明, 刘欣宇, 等. 场发射电推力器的研究现状及其关键技术[J]. 火箭推进, 2018, 44(4): 1-9.
GUO D S, KANG X M, LIU X Y, et al. Research status and key technologies of field emission electric propulsion thruster[J]. Journal of Rocket Propulsion, 2018, 44(4): 1-9.
[2]于达仁, 牛翔, 王泰卜, 等. 面向空间引力波探测任务的微推进技术研究进展[J]. 中山大学学报(自然科学版), 2021, 60(1): 194-212.
YU D R, NIU X, WANG T B, et al. The developments of micro propulsion technology based on space gravitational wave detection task[J]. Acta Scientiarum Naturalium Universitatis Sunyatseni, 2021, 60(1): 194-212.
[3]GONG Y G, LUO J, WANG B. Concepts and status of Chinese space gravitational wave detection projects[J]. Nature Astronomy, 2021, 5: 881-889.
[4]陈茂林, 刘旭辉, 周浩浩, 等. 适用于微纳卫星的微型电推进技术研究进展[J]. 固体火箭技术, 2021, 44(2): 188-206.
CHEN M L, LIU X H, ZHOU H H, et al. Research and development of micro electric propulsion technology for micro/nano satellites[J]. Journal of Solid Rocket Technology, 2021, 44(2): 188-206.
[5]于达仁, 乔磊, 蒋文嘉, 等. 中国电推进技术发展及展望[J]. 推进技术, 2020, 41(1): 1-11.
YU D R, QIAO L, JIANG W J, et al. Development and prospect of electric propulsion technology in China[J]. Journal of Propulsion Technology, 2020, 41(1): 1-11.
[6]LEGGE R S, LOZANO P, MARTINEZ-SANCHEZ M. Fabrication and characterization of porous metal emitters for electrospray thrusters[C]//30th International Electric Propulsion Conference. Florence, Italy: IEPC, 2007.
[7]CHEN C, CHEN M L, ZHOU H H. Characterization of an ionic liquid electrospray thruster with a porous ceramic emitter[J]. Plasma Science and Technology, 2020, 22(9): 094009.
[8]LIU X Y, KANG X M, DENG H W, et al. Energy properties and spatial plume profile of ionic liquid ion sources based on an array of porous metal strips[J]. Plasma Science and Technology, 2021, 23(12): 125502.
[9]张天平, 张雪儿, 李璇. 离子与霍尔电推进性能和质量的工程数据模型[J]. 火箭推进, 2022, 48(1): 1-13.
ZHANG T P, ZHANG X E, LI X. Engineering data models of performance and mass for ion and Hall electric propulsions[J]. Journal of Rocket Propulsion, 2022, 48(1): 1-13.
[10]ZIEMER J, MARRESE-READING C, CUTLER C, et al. In-flight verification and validation of colloid micro-thruster performance[C]//2018 Joint Propulsion Conference. Reston, Virginia: AIAA, 2018.
[11]KREJCI D, MIER-HICKS F, FUCETOLA C P, et al. Design and characterization of a scalable ion electrospray propulsion system[C]//30th International Symposium on Space Technology and Science. Hyogo, Japan: ISTS, 2015.
[12]JORNS B A, GORODETSKY A A, LASKY I M, et al. Uncertainty quantification of electrospray thruster array lifetime[C]//36th International Electric Propulsion Conference. [S.l.]: IEPC, 2019.
[13]ST PETER B, DRESSLER R A, CHIU Y H, et al. Electrospray propulsion engineering toolkit(ESPET)[J]. Aerospace, 2020, 7(7): 91.
[14]雪佳强, 郭宁, 孟伟, 等. 多孔阵列式电喷雾推力器纯离子电流的物理模型[J]. 推进技术, 2023, 44(6): 171-182.
XUE J Q, GUO N, MENG W, et al. Physical model for current of electrospray thruster with porous emitter array operated in pure ionic regime[J]. Journal of Propulsion Technology, 2023, 44(6): 171-182.
[15]DRESSLER R A, PETER B S, CHIU Y H, et al. Multiple emission sites on porous glass electrospray propulsion emitters using dielectric propellants [J]. Journal of Propulsion and Power, 2022, 38(5): 809-821.
[16]NATISIN M R, ZAMORA H L. Performance of a fully conventionally machined liquid-ion electrospray thruster operated in PIR[C]//36th International Electric Propulsion Conference. [S.l]: IEPC, 2019.
[17]WHITTAKER C B, GORODETSKY A, JORNS B. Quantifying uncertainty in the scaling laws of porous electrospray emitters[C]//AIAA Propulsion and Energy 2020 Forum. Reston, Virginia: AIAA, 2020.
[18]WRIGHT P, WIRZ R E. Transient flow in porous electrospray emitters[C]//AIAA Propulsion and Energy 2021 Forum. Reston, Virginia: AIAA, 2021.
[19]程世豪. 离子液体微型电推进器三维仿真与性能分析[D]. 南京: 南京航空航天大学, 2017.
CHENG S H. Three dimensional simulation and performance analysis of ionic liquid micro thruster[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2017.
[20]COFFMAN C, ANCHEZ M, HIGUERA F J, et al. Structure of the menisci of leaky dielectric liquids during electrically-assisted evaporation of ions[J]. Applied Physics Letters, 2016, 109(23): 231602.
[21]VIRTANEN P, GOMMERS R, OLIPHANT T E, et al. SciPy 1.0: fundamental algorithms for scientific computing in Python[J]. Nature Methods, 2020, 17(3): 261-272.
[22]SOBOL I M. Global sensitivity indices for nonlinear mathematical models and their Monte Carlo estimates[J]. Mathematics and Computers in Simulation, 2001, 55(1/2/3): 271-280.
[23]SALTELLI A, ANNONI P, AZZINI I, et al. Variance based sensitivity analysis of model output. Design and estimator for the total sensitivity index[J]. Computer Physics Communications, 2010, 181(2): 259-270.
[24]HERMAN J, USHER W. SALib: an open-source Python library for sensitivity analysis[J]. The Journal of Open Source Software, 2017, 2(9): 97.
[25]YANG Y T, GUO D W, LI X K, et al. Development and characterization of a novel porous-media borosilicate glass ion sources for electrospray thruster[J]. Aerospace, 2021, 8(10): 297.
[26]NATISIN M R, ZAMORA H L, HOLLEY Z A, et al. Efficiency mechanisms in porous-media electrospray thrusters[J]. Journal of Propulsion and Power, 2021, 37(5): 650-659.
[27]NATISIN M R, ZAMORA H L, MCGEHEE W A, et al. Fabrication and characterization of a fully conventionally machined, high-performance porous-media electrospray thruster[J]. Journal of Micromechanics and Microengineering, 2020, 30(11): 115021.

备注/Memo

收稿日期:2023- 05- 11 修回日期:2023- 06- 06
基金项目:国家重点研发计划引力波探测专项(2021YFC2202704)
作者简介:雪佳强(1999—),男,硕士,研究领域为离子液体电喷雾推进技术。

更新日期/Last Update: 1900-01-01